 |
Material Safety Data
Sheet | The Valvoline Company Date Prepared: 02/10/95
Date Printed: 10/18/99
MSDS No: 503.0188368-001.008I
MAC'S LIQUID CAR WASH CONCENTRATE
__________________________________________________________________________
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Material Identity
Product Name: MAC'S LIQUID CAR WASH CONCENTRATE
General or Generic ID: DETERGENT
Company Telephone Numbers
The Valvoline Company Emergency: 1-800-274-5263
P.O. Box 14000
Lexington, KY 40512 Information: 1-606-357-7847
__________________________________________________________________________
2. COMPOSITION/INFORMATION ON INGREDIENTS
Ingredient(s) CAS Number % (by weight)
-------------------------------------------- ------------- -------------
DETERGENT 100.0
__________________________________________________________________________
3. HAZARDS IDENTIFICATION
Potential Health Effects
Eye
Can cause eye irritation. Symptoms include stinging, tearing,
redness, and swelling of eyes.
Skin
Can cause skin irritation. Symptoms may include redness and
burning of skin, and other skin damage.
Swallowing
Swallowing small amounts of this material during normal handling
is not likely to cause harmful effects. Swallowing large amounts
may be harmful.
Inhalation
Breathing of vapor or mist is possible.
Symptoms of Exposure
stomach or intestinal upset (nausea, vomiting, diarrhea),
irritation (nose, throat, airways).
Target Organ Effects
No data
Developmental Information
No data
Cancer Information
No data
Other Health Effects
No data
Primary Route(s) of Entry
Skin contact.
__________________________________________________________________________
4. FIRST AID MEASURES
Eyes
If symptoms develop, immediately move individual away from
exposure and into fresh air. Flush eyes gently with water for at
least 15 minutes while holding eyelids apart; seek immediate
medical attention.
Skin
Remove contaminated clothing. Wash exposed area with soap and
water. If symptoms persist, seek medical attention. Launder
clothing before reuse.
Swallowing
If swallowed, seek medical attention. If individual is drowsy or
unconscious, do not give anything by mouth; place individual on
the left side with the head down. If individual is conscious and
alert, induce vomiting by giving syrup of ipecac or by gently
placing two fingers at the back of the throat. If possible, do
not leave individual unattended.
Inhalation
If symptoms develop, move individual away from exposure and into
fresh air. If symptoms persist, seek medical attention. If
breathing is difficult, administer oxygen. Keep person warm and
quiet; seek immediate medical attention.
Note to Physicians
No data
__________________________________________________________________________
5. FIRE FIGHTING MEASURES
Flash Point
Not applicable
Explosive Limit
No data
Autoignition Temperature
No data
Hazardous Products of Combustion
No data
Fire and Explosion Hazards
No data
Extinguishing Media
alcohol foam, water fog.
Fire Fighting Instructions
No special precautions necessary when fighting fires involving
this product.
NFPA Rating
Health - 1, Flammability - 0, Reactivity - 0
__________________________________________________________________________
6. ACCIDENTAL RELEASE MEASURES
Small Spill
Absorb liquid on vermiculite, floor absorbent or other absorbent
material.
Large Spill
Persons not wearing protective equipment should be excluded from
area of spill until clean-up has been completed. Stop spill at
source, dike area of spill to prevent spreading, pump liquid to
salvage tank. Remaining liquid may be taken up on sand, clay,
earth, floor absorbent, or other absorbent material and shoveled
into containers.
__________________________________________________________________________
7. HANDLING AND STORAGE
Handling
Containers of this material may be hazardous when emptied. Since
emptied containers retain product residues (vapor, liquid, and/or
solid), all hazard precautions given in the data sheet must be
observed.
Storage
Not applicable
__________________________________________________________________________
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Eye Protection
Wear safety glasses in compliance with OSHA regulations. (Consult
your safety representative.)
Skin Protection
Not normally required., Other protective equipment: not required
under normal conditions of use..
Respiratory Protections
Not required under normal conditions of use.
Engineering Controls
Not required under normal conditions of use.
Exposure Guidelines
Component
----------
DETERGENT
No exposure limits established
__________________________________________________________________________
9. PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point
(for product) 212.0 - 214.0 F (100.0 - 101.1 C) @ 760.00 mmHg
Vapor Pressure
Not applicable
Specific Vapor Density
> 1.000 @ AIR=1
Specific Gravity
1.040 - 1.050 @ 60.00 F
Liquid Density
8.660 lbs/gal @ 60.00 F
1.040 kg/l @ 15.60 C
Percent Volatiles (Including Water)
No data
Evaporation Rate
< 1.00 (BUTYL ACETATE )
Appearance
No data
State
LIQUID
Physical Form
HOMOGENEOUS SOLUTION
Color
DEEP BLUE, FRESH SCENT
Odor
No data
pH
7.2 - 7.8
__________________________________________________________________________
10. STABILITY AND REACTIVITY
Hazardous Polymerization
Product will not undergo hazardous polymerization.
Hazardous Decomposition
No data
Chemical Stability
Stable.
Incompatibility
Avoid contact with: strong mineral acids.
__________________________________________________________________________
11. TOXICOLOGICAL INFORMATION
No data
__________________________________________________________________________
12. ECOLOGICAL INFORMATION
No data
__________________________________________________________________________
13. DISPOSAL CONSIDERATION
Waste Management Information
Dispose of in accordance with all applicable local, state and
federal regulations.
__________________________________________________________________________
14. TRANSPORT INFORMATION
DOT Information - 49 CFR 172.101
DOT Description:
Not Regulated
Container/Mode:
CASES/SURFACE - NO EXCEPTIONS
NOS Component:
None
RQ (Reportable Quantity) - 49 CFR 172.101
Not applicable
__________________________________________________________________________
15. REGULATORY INFORMATION
US Federal Regulations
TSCA (Toxic Substances Control Act) Status
TSCA (UNITED STATES) The intentional ingredients of this
product are listed.
CERCLA RQ - 40 CFR 302.4
None
SARA 302 Components - 40 CFR 355 Appendix A
None
Section 311/312 Hazard Class - 40 CFR 370.2
Immediate(X) Delayed( ) Fire( ) Reactive( ) Sudden
Release of Pressure( )
SARA 313 Components - 40 CFR 372.65
None
International Regulations
Inventory Status
Not determined
State and Local Regulations
California Proposition 65
None
__________________________________________________________________________
16. OTHER INFORMATION
The information accumulated herein is believed to be accurate but
is not warranted to be whether originating with the company or
not. Recipients are advised to confirm in advance of need that the
information is current, applicable, and suitable to their
circumstances.
Last Page
|